利用催化气相化学沉积(Catalytic chemical vapor deposition,CCVD)法在炭纸上原位生长得到CNF/CP复合体,并对这种复合体的物理化学性能和氧气电催化还原反应(Oxygen reduction reaction,ORR)性能进行了研究.结果表明:纳米炭纤维较为均匀地分散在炭纸上,其中纳米炭纤维具有窄的直径分布.所制CNF/CP复合体具有较大的比表面积和独特的中孔结构；相对于炭纸,CNF/CP复合体的端面碳原子和基面碳原子比例较高.另外,CNF/CP还具有较高的ORR反应活性,其ORR为2电子反应过程,原因可以归结于纳米炭纤维独特的微结构.同时,CNF/CP也具有较高的交换电流密度和较正的平衡电压.
A carbon nanofiber/carbon paper (CNF/CP) composite was synthesized directly on CP by a catalytic chemical vapor-deposition method,and the physicochemical properties of and oxygen-reduction reaction (ORR) on this composite were investigated.Scanning electron microscopy shows that the CNFs are uniformly distributed on the CP,and high-resolution transmission electron microscopy results show that the CNFs have a narrow size distribution.The CNF/CP composite has a large surface area,and its mesoporous character is confirmed by N2physisorption.Raman spectrum studies show that the CNF/CP composite has a high ratio of edge atoms to basal atoms compared with that of CP.From cyclic voltammetry studies,the CNF/CP composite was found to be more active than CP in terms of ORR,which may be due to the contribution from the CNFs.The CNF/CP composite shows a higher exchange current density and more positive equilibrium potential than CP,as verified by Tafel analysis.Moreover,linear-sweep voltammetry confirms that ORR on the CNF/CP composite is conducted through a two-electron reaction pathway.
参考文献
| [1] | Michael Ball;Martin Wietschel .The Future Of Hydrogen - Opportunities And Challenges1[J].International journal of hydrogen energy,2009(2):615-627. |
| [2] | Gregorio Marban;Teresa Valdes-Solis .Towards the hydrogen economy?[J].International journal of hydrogen energy,2007(12):1625-1637. |
| [3] | Arico A S;Srinivasan S;Antonucci V .DMFCs-from fundamental aspects to technology development[J].Fuel Cells,2001,1(02):133-116. |
| [4] | Kwong-Yu Chan;Jie Ding;Jiawen Ren;Shaoan Cheng;KWOK YING TSANG .Supported mixed metal nanoparticles as electrocatalysts in low temperature fuel cells[J].Journal of Materials Chemistry: An Interdisciplinary Journal dealing with Synthesis, Structures, Properties and Applications of Materials, Particulary Those Associated with Advanced Technology,2004(4):505-516. |
| [5] | Loffler M S;Gross B;Natter H et al.New preparation technique and characterisation of nanosttuctured catalysts for polymer membrane fuel cells[J].Physical Chemistry Chemical Physics,2001,3(8-9):333-338. |
| [6] | A. Lima;C. Coutanceau;J. - M. Leger;C. Lamy .Investigation of ternary catalysts for methanol electrooxidation[J].Journal of Applied Electrochemistry,2001(4):379-386. |
| [7] | Katsuaki S;Kohei U;Hideaki K et al.Structure of Pt microparticles dispersed electrochemically onto glassy carbon electrodes:Examination with the scanning tunneling microscope and the scanning electron microscope[J].Journal of Electroanalytical Chemistry,1988,256:481-487. |
| [8] | Watanabe M;Saegusa S;Stonelhart P .High platinum electrocatalyst utilizations for direct methanol oxidation[J].Journal of Electroanalytical Chemistry,1989,271(1-2):213-220. |
| [9] | S. Lj. Gojkovic;T. R. Vidakovic .Methanol oxidation on an ink type electrode using Pt supported on high area carbons[J].Electrochimica Acta,2001(4):633-642. |
| [10] | Scott D.Thompson;Larry R.Jordan;Maria Forsyth .Platinum electrodeposition for polymer electrolyte membrane fuel cells[J].Electrochimica Acta,2001(10/11):1657-1663. |
| [11] | Marcinkoski J;Kopasz J P;Benjamin T G .Int.Progress in the US DOE fuel cell subprogram efforts in polymer electrolyte fuel cells[J].Journal of Hydrogen Energy,2008,33(14):3894-3902. |
| [12] | Renschler C L;Pouch J J;Cox D M.Editors.Novel Forms of Carbon:Materials Research Society Symposium Proceedings[M].Pittsburgh,PA 15237,USA |
| [13] | E. Passalacqua;F. Lufrano;G. Squadrito;A. Patti;L. Giorgi .Nafion content in the catalyst layer of polymer electrolyte fuel cells: effects on structure and performance[J].Electrochimica Acta,2001(6):799-805. |
| [14] | Cheng Wang;Mahesh Waje;Xin Wang;Jason M. Tang;Robert C. Haddon;Yushan Yan .Proton Exchange Membrane Fuel Cells with Carbon Nanotube Based Electrodes[J].Nano letters,2004(2):345-348. |
| [15] | Zheng JS;Zhang XS;Li P;Zhu J;Zhou XG;Yuan WK .Effect of carbon nanofiber microstructure on oxygen reduction activity of supported palladium electrocatalyst[J].Electrochemistry communications,2007(5):895-900. |
| [16] | Dai H .Carbon nanotubes:opportunities and challenges[J].Surface Science,2002,500:218-241. |
| [17] | Ledoux MJ.;Vieira R.;Pham-Huu C.;Keller N. .New catalytic phenomena on nanostructured (fibers and tubes) catalysts[J].Journal of Catalysis,2003(1/2):333-342. |
| [18] | De Jong KP.;Geus JW. .Carbon nanofibers: Catalytic synthesis and applications [Review][J].Catalysis Reviews. Science and Engineering,2000(4):481-510. |
| [19] | Chen D;Christensen K O;Ochoa-Fernández E et al.Synthesis of carbon nanofibers:efects of Ni crystal size during methane decomposition[J].Journal of Catalysis,2005,229(24):82-96. |
| [20] | Zlao T J .Studies on the microstructure control of carbon nanofiber and relative catalytic properties[D].Doying:East China University of Science and Technology,2004. |
| [21] | Li, P;Li, T;Zhou, JH;Sui, ZJ;Dai, YC;Yuan, WK;Chen, D .Synthesis of carbon nanofiber/graphite-felt composite as a catalyst[J].Microporous and Mesoporous Materials,2006(1/3):1-7. |
| [22] | Jun-Sheng Zheng;Xin-Sheng Zhang;Ping Li;Xing-Gui Zhou;De Chen;Ye Liu;Wei-Kang Yuan .Oxygen reduction reaction properties of carbon nanofibers: Effect of metal purification[J].Electrochimica Acta,2008(10):3587-3596. |
| [23] | Z.R.Ismagilov;M.A.Ker/hentsev;N.V.Shikina;A.S.Lisitsyn;L.B.Okhlopkova;Ch.N.Barnakov;Masao Sakashita;Takashi Iijima;Kenichiro Tadokoro .Development of active catalysts for low Pt loading cathodes of PEMFC by surface tailoring of nanocarbon materials[J].Catalysis Today,2005(0):58-66. |
| [24] | Jun-Sheng Zheng;Xin-Sheng Zhang;Ping Li .Microstructure effect of carbon nanofiber on electrocatalytic oxygen reduction reaction[J].Catalysis Today,2008(1/4):270-277. |
| [25] | T. V. Reshetenko;L. B. Avdeeva;Z. R. Ismagilov .Catalytic filamentous carbon Structural and textural properties[J].Carbon: An International Journal Sponsored by the American Carbon Society,2003(8):1605-1615. |
| [26] | Yan W;Alsmeyer D C;McCreery R L .Raman spectroscopy of carbon materials:structural basis of observed spectra[J].Chemistry of Materials,1990,2(05):557-563. |
| [27] | Marjolein L.Toebes;Johannes H.Bitter;A.Jos van Dillen;Krijn P.de Jong;Frans F.Prinsloo .Influence of oxygen-containing surface groups on the activity and selectivity of carbon nanofiber-Spported ruthenium catalysts in the hydrogenation of cinnamaldehyde[J].Journal of Catalysis,2003(1):78-87. |
| [28] | P. Li;T.-J. Zhao;J.-H. Zhou .Characterization of carbon nanofiber composites synthesized by shaping process[J].Carbon: An International Journal Sponsored by the American Carbon Society,2005(13):2701-2710. |
| [29] | Maldonado S;Stevenson K J .Direct preparation of cadbon nanofiber electrode via pyrolysis of iron (Ⅱ) phthalocyanine:Electrocatlytic aspects for oxygen reduction[J].Journal of Physical Chemistry B,2004,108(31):11375-11383. |
| [30] | Marjolein L.Toebes;Johannes H.Bitter;A.Jos van Dillen;Krijn P.de Jong;Frans F.Prinsloo .Influence of oxygen-containing surface groups on the activity and selectivity of carbon nanofiber-Spported ruthenium catalysts in the hydrogenation of cinnamaldehyde[J].Journal of Catalysis,2003(1):78-87. |
| [31] | Yeager E .Dioxygen electrocatalysis:mechanisms in relation to catalyst structure[J].Journal of Mol Cater,1986,38(12):5-25. |
| [32] | Apple M;Appleby A J .A ring-disk electrode study of the reduction of oxygen on active carbon in alkaline solution[J].Electrochimica Acta,1978,23(11):1243-1246. |
| [33] | Appleby A J .Oxygen reduction on oxide-free platinum in 85%orthophosphoric acid:temperature and impurity dependence[J].Journal of the Electrochemical Society,1970,117(03):328-335. |
| [34] | Tryk D;Cabrera C R;Fujishima A.Fundamental Understanding of Electrode Processes in Memory of Professor Ernest B.Yeager[A].New Jersey,2005:45-56. |
| [35] | T. Yano;E. Popa;D. A. Tryk;K. Hashimoto;A. Fujishima .Electrochemical behavior of highly conductive boron-doped diamond electrodes for oxygen reduction in acid solution[J].Journal of the Electrochemical Society,1999(3):1081-1087. |
| [36] | JUN-ICHI OZAKI;KIYOMI NOZAWA;KUNITAKA YAMADA .Structures, physicochemical properties and oxygen reduction activities of carbons derived from ferrocene-poly(furfuryl alcohol) mixtures[J].Journal of Applied Electrochemistry,2006(2):239-247. |
| [37] | Bennett J A;Wang J;Show Y et al.The Effect of sp2-bonded nondiamond carbon impurity on the physical and electrochemical properties of boron-doped polycrystalline diamond thin-film electrodes[J].Journal of the Electrochemical Society,2004,151:E306-E313. |
| [38] | Britto PJ.;Rubio A.;Alonso JA.;Ajayan PM.;Santhanam KSV. .Improved charge transfer at carbon nanotube electrodes[J].Advanced Materials,1999(2):154-157. |
| [39] | Lin Y H;Cui X L;Yen C et al.Platinum/cadbon nanotube nanocomposite synthesized in supercritical fluid as electrocatalysts for low-temperature fuel cells[J].Journal of Physical Chemistry B,2005,109:14410-14415. |
| [40] | Zecevic SK.;Litt MH.;Gojkovic SL.;Savinell RF.;Wainright JS. .KINETICS OF O-2 REDUCTION ON A PT ELECTRODE COVERED WITH A THIN FILM OF SOLID POLYMER ELECTROLYTE[J].Journal of the Electrochemical Society,1997(9):2973-2982. |
| [41] | Salvador-Pascuala J J;Citalán-Cigarroaa S;Solorza-Feria O .Kinetics of oxygen reduction reaction on nanosized Pd electrocatalyst in acid media[J].Journal of Power Sources,2007,172(11):229-234. |
| [42] | Otake Y;Jenkins R G .Characterization of oxygen-containing surface complexes created on a microporous carbon by air and nitric-acid treatment[J].CARBO,1993,31(01):109-121. |
| [43] | Nagaoka T;Sakai T;Ogura K et al.Surface properties of electrochemically pretreated glassy carbon[J].Analytical Chemistry,1986,58(09):1953-1955. |
| [44] | Maldonado S;Stevenson K J .Influence of nitrogen doping on oxygen electrocatalysis at carbon nanofiber electrodes[J].Journal of Physical Chemistry B,2005,109(10):4707-4716. |
| [45] | Sidik R A;Anderson A B;Subramanian N P et al.O2 reduction on graphite and nitrogen-doped graphite:experiment and theory[J].Journal of Physical Chemistry B,2006,110:1787-1793. |
| [46] | Xu W L .Studies on key technologies and relative electrochemical basis for proton exchange membrane fuel cells[D].长春:中国科学院长春应用化学研究所,2006. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%