采用高压釜模拟高温高压法进行从载金炭上解吸金的试验，并研究了解吸过程中解吸液NaOH质量分数、解吸时间、载金炭钙质量分数对炭强度的影响。其结果表明：解吸液中NaOH质量分数大于2％时对炭的强度影响较大；在保证金解吸率高于95％的前提下，解吸时间越短对炭强度衰减影响越小；载金炭钙质量分数低于2％时对解吸过程中炭强度的影响较小，当载金炭钙质量分数高于4％时对解吸过程中炭强度的影响较大。此研究对实际生产中减少解吸过程中炭的磨损、粉化具有一定指导意义。
Autoclave is used to simulate the method of stripping gold from gold laden carbon with high tempera-ture and pressure in the laboratory .The influences of NaOH concentration in desorbing agent ,desorption time and the calcium content in gold laden carbon on carbon strength are studied .The results show that NaOH concentration in de-sorbing agent being more than 2%has a great influence on carbon strength;in the premise of the gold desorption rate being higher than 95%,the shorter desorption time is ,the smaller impact it has on carbon strength attenuation;when the calcium content of gold laden carbon is lower than 2 %, It has less influence on carbon strength in stripping process;when calcium content of gold laden carbon is higher than 4%,it has greater influence on carbon strength in stripping process .This study is significant to reduce the wear and pulverization of carbon in stripping process for the actual production .
参考文献
| [1] | 胡斌;刘子龙 .对高温高压无氰解吸电解工艺中粉(碎)炭问题的分析[J].黄金学报,1999,3(01):189-193. |
| [2] | 刘豹,梁国海,于海龙.高温高压解吸电解工艺中粉炭金的回收[J].辽宁科技大学学报,2008(02):132-134. |
| [3] | 刘立新.高温高压解吸电解工艺中生成粉炭的研究[J].黄金,2005(11):40-42. |
| [4] | 杨坤彬,彭金辉,郭胜惠,张利波,黄孟阳,夏洪应,张世敏.提金活性炭的研究现状及其展望[J].黄金,2007(01):46-50. |
| [5] | GB/T 12496-1999.活性炭的标准试验方法[S].北京:中国标准出版社,1999. |
| [6] | 余关平.载金炭解吸率低原因分析及预防措施[J].黄金,2011(05):45-48. |
| [7] | 范必威,王秀英,张华兵.不同形态钙对活性炭活性的影响及其消除方法的研究[J].黄金,2002(07):25-27. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%