采用线性离子束沉积技术于AZ80镁合金微弧氧化(MAO)陶瓷层表面沉积不同厚度的类金刚石碳(DLC)膜,形成DLC/MAO复合膜层.对比研究4种膜基系统的表面结构特征、力学性能以及摩擦学性能差异.结果表明:随DLC膜厚度增加,复合膜层表面微孔数量减少,孔径减小,但凹凸不平趋势增加,且DLC膜表面颗粒特征更加明显,表现为DLC-80min/MAO/AZ80膜基系统具有最小的表面粗糙度,最大的硬度H、弹性模量E及H/E值；不同厚度DLC/MAO/AZ80膜基系统平均摩擦因数较MAO/AZ80显著降低；DLC膜厚度增加导致3种复合膜基系统的表面微观结构改变,使得摩擦因数与磨痕形貌存在差异；各膜基系统表面磨痕处均形成了Fe的转移层,由于表层DLC膜“裸露”的大量C对磨损界面具有很好的润滑作用,而使得镁合金基体获得有效保护.
参考文献
| [1] | Zhang, Y.;Yang, J.X.;Cui, F.Z.;Lee, I.-S.;Lee, G.-H. .Characterization and degradation comparison of DLC film on different magnesium alloys[J].Surface & Coatings Technology,2010(S1):S15-S20. |
| [2] | Hongping Duan;Keqin Du;Chuanwei Yan;Fuhui Wang .Electrochemical corrosion behavior of composite coatings of sealed MAO film on magnesium alloy AZ91D[J].Electrochimica Acta,2006(14):2898-2908. |
| [3] | Uematsu, Y.;Kakiuchi, T.;Teratani, T.;Harada, Y.;Tokaji, K. .Improvement of corrosion fatigue strength of magnesium alloy by multilayer diamond-like carbon coatings[J].Surface & Coatings Technology,2011(8/9):2778-2784. |
| [4] | Yamauchi N;Demizu K;Ueda N;Sone T;Tsujikawa M;Hirose Y .Effect of peening as pretreatment for DLC coatings on magnesium alloy[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2006(0):378-383. |
| [5] | 夏登福,许晓静,卓刘成,郝欣妮,宗亮.磁控溅射DLC/SiC/Ti多层膜对镁合金摩擦磨损性能的影响[J].航空材料学报,2009(04):47-51. |
| [6] | Ikeyama M;Nakao S;Miyagawa Y;Miyagawa S .Effects of Si content in DLC films on their friction and wear properties[J].Surface & Coatings Technology,2005(1):38-42. |
| [7] | Ikeyama Masami;Nakao Setsuo;Sonoda Tsutomu;Choi Junho .Improvement of corrosion protection property of Mg-alloy by DLC and Si-DLC coatings with PBII technique and multi-target DC-RF magnetron sputtering[J].Nuclear Instruments and Methods in Physics Research, Section B. Beam Interactions with Materials and Atoms,2009(8/9):1675-1679. |
| [8] | P. Papakonstantinou;J.F. Zhao;A. Richardot;E.T. McAdams;J.A. McLaughlin .Evaluation of corrosion performance of ultra-thin Si-DLC overcoats with electrochemical impedance spectroscopy[J].Diamond and Related Materials,2002(3-6):1124-1129. |
| [9] | Yamauchi N;Demizu K;Ueda N;Cuong NK;Sone T;Hirose Y .Friction and wear of DLC films on magnesium alloy[J].Surface & Coatings Technology,2005(1/3):277-282. |
| [10] | P. Papakonstantinou;J.F Zhao;P. Lemoine;E.T. McAdams;J.A. McLaughlin .The effects of Si incorporation on the electrochemical and nanomechanical properties of DLC thin films[J].Diamond and Related Materials,2002(3-6):1074-1080. |
| [11] | Wei Dai;Guosong Wu;Aiying Wang .Preparation, characterization and properties of Cr-incorporated DLC films on magnesium alloy[J].Diamond and Related Materials,2010(10):1307-1315. |
| [12] | J. Choi;S. Nakao;J. Kim .Corrosion protection of DLC coatings on magnesium alloy[J].Diamond and Related Materials,2007(4/7):1361-1364. |
| [13] | WU G S;DAI W;ZHENG H et al.Improving wear resistance and corrosion resistance of AZ31 magnesium alloy by DLC/A1N/Al coating[J].Surface and Coatings Technology,2010,205(07):2067-2073. |
| [14] | Wang CX;Zhang D;Jiang YF .Growth process and wear resistance for ceramic coatings formed on Al-Cu-Mg alloy by micro-arc oxidation[J].Applied Surface Science: A Journal Devoted to the Properties of Interfaces in Relation to the Synthesis and Behaviour of Materials,2006(2):674-678. |
| [15] | Y.M. Wang;B.L. Jiang;L.X. Guo;T.Q. Lei .Tribological behavior of microarc oxidation coatings formed on titanium alloys against steel in dry and solid lubrication sliding[J].Applied Surface Science: A Journal Devoted to the Properties of Interfaces in Relation to the Synthesis and Behaviour of Materials,2006(8):2989-2998. |
| [16] | ZHANGYJ;YANCW;WANGFH et al.Study on the environmentally friendly anodizing of AZ91D magnesium alloy[J].Surface and Coatings Technology,2002,161(01):36-43. |
| [17] | Jun Liang;Peng Wang;Litian Hu .Tribological properties of duplex MAO/DLC coatings on magnesium alloy using combined microarc oxidation and filtered cathodic arc deposition[J].Materials Science & Engineering, A. Structural Materials: Properties, Misrostructure and Processing,2007(0):164-169. |
| [18] | Fox-Rabinovich GS;Beake BD;Enchino JL;Veldhuis SC;Parkinson R;Shuster LS;Migranov MS .Effect of mechanical properties measured at room and elevated temperatures on the wear resistance of cutting tools with TiAlN and AlCrN coatings[J].Surface & Coatings Technology,2006(20/21):5738-5742. |
| [19] | Bias effects on the tribological behavior of cathodic arc evaporated CrTiAlN coatings on AISI 304 stainless steel[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2010(14):p.3825. |
| [20] | 杨巍,蒋百灵,鲜林云.溶质离子在镁合金微弧氧化膜形成过程中的作用[J].材料热处理学报,2009(01):157-160. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%