利用中间相沥青纤维的自粘结性和沥青大分子沿纤维轴高度择优取向的特点,通过热压方法制备高导热块体碳材料.在纺丝和氧化条件不变的情况下,主要考察了中间相沥青的熔融纺丝温度对纤维性能和目标材料性能的影响.结果显示:(1)熔融纺丝温度越高,中间相沥青纤维的直径越大;(2)在合适的纺丝温度下所得的纤维经氧化后热压制得材料具有较高的弯曲强度、密度、热导率以及较低的电阻率.选取纺丝温度为308℃,所纺中间相纤维直径为20μm,氧化后经热压所得材料的密度、弯曲强度、热导率和电阻率分别为2.02g/cm3、128.7 MPa、597W/(m·K)和1.25μΩ·m.
参考文献
| [1] | 孙乐民,李贺军,张守阳.沥青基碳／碳复合材料的组织特性[J].无机材料学报,2000(06):1111-1116. |
| [2] | Fitzer E .The future of carbon-carbon composites[J].Carbon,1987,25(02):163-190. |
| [3] | Hugh O Pieson.handbook of carbon,graphite,diamond and fullenenesroperties,processing and application[M].USA.Noyes Publication,1993:51-63. |
| [4] | S. BLAZEWICZ;J. BLOCKI;J. CHLOPEK;J. GODLEWSKI;J. MICHALOWSKI;K. PAKONSKI;J. PIEKARCZYK;M. STODULSKI .THIN C/C COMPOSITE SHELLS FOR HIGH ENERGY PHYSICS: MANUFACTURE AND PROPERTIES[J].Carbon: An International Journal Sponsored by the American Carbon Society,1996(11):1393-1399. |
| [5] | 邱海鹏,郭全贵,翟更太,宋永忠,刘朗.粘结剂对石墨材料的物理性能及微观结构影响的研究[J].宇航材料工艺,2001(06):23-26. |
| [6] | Adams PM.;Rellick GS.;Stupian GW.;Katzman HA. .Characterization of high thermal conductivity carbon fibers and a self-reinforced graphite panel[J].Carbon: An International Journal Sponsored by the American Carbon Society,1998(3):233-245. |
| [7] | 邱海鹏,宋永忠,郭全贵,翟更太,刘朗.高导热炭纤维及其炭基复合材料[J].功能材料,2002(05):473-476. |
| [8] | Hoffman W R;Huttinger K J .Singtering of powders polyaromatic mesophase to high-strength isotropic carbons-Ⅰ[J].CARBON,1994,32(06):1087-1130. |
| [9] | Gschwindt A;Huttinger K J .Sintering of powders polyaromatic mesophase to high-strength isotropic carbons-Ⅱ[J].CARBON,1994,32(06):1105-1118. |
| [10] | M. BRAUN;K. J. HUETTINGER .SINTERING OF POWDERS OF POLYAROMATIC MESOPHASE TO HIGH-STRENGTH ISOTROPIC CARBONS: Ⅲ. POWDERS BASED ON AN IRON-CATALYZED MESOPHASE SYNTHESIS[J].Carbon: An International Journal Sponsored by the American Carbon Society,1996(12):1473-1491. |
| [11] | Mochida I .Self-adhesive carbon grains oxidatively prepared from naphthalene-derived mesophase pitch for mould of high density[J].CARBON,1994,32(05):961-969. |
| [12] | 凌力成;陈玉琴;吴东.中间相沥青纤维的氧化稳定化及碳化[J].炭素技术,1995(06):14-19. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%