简要综述了浓差极化和膜污染的研究方法和策略.利用超滤法处理印钞擦版废液实验说明研究思路和各种分析方法的应用.通过膜阻力模型实验,分析出各污染途径产生的阻力大小,讨论了应注意的问题.采用EDX,ICP,TOC,SEM,FTIR和MC对膜污染物、酸洗和碱洗液、清洗前后膜表面形貌分析鉴定,发现主要无机污染物是钙离子,主要有机污染物是磺化蓖麻油.模拟实验结果与上述结果一致,并引导出四步清洗方法,可对污染膜进行有效清洗;并发现对于严重污染的膜,采用三个以上清洗周期才能使膜通量得到完全恢复.最后提出一个浓差极化和膜污染的研究方法和策略框架图.
参考文献
| [1] | Sheikholeslami R .Fouling mitigation in membrane processes[J].Desalination,1999,123:45-53. |
| [2] | Maxime Pontie;Sophie Rapenne;Anju Thekkedath;Jean Duchesne;Valerie Jacquemet;Jerome Leparc;Herve Suty .Tools for membrane autopsies and antifouling strategies in seawater feeds:a review[J].Desalination: The International Journal on the Science and Technology of Desalting and Water Purification,2005(1/3):75-90. |
| [3] | Chen, JC;Li, QL;Elimelech, M .In situ monitoring techniques for concentration polarization and fouling phenomena in membrane filtration[J].Advances in Colloid and Interface Science,2004(2/3):83-108. |
| [4] | 刘忠洲,续曙光,李锁定.微滤、超滤过程中的膜污染与清洗[J].水处理技术,1997(04):187. |
| [5] | 刘忠洲.膜过程的浓差极化和膜污染[A].北京:化学工业出版社,2001:171-177. |
| [6] | 王晓琳.膜的污染和劣化及其防治对策[J].工业水处理,2001(09):1-5. |
| [7] | Fane A G;Fell C J D .A review of fouling and fouling control in ultrafiltration[J].DESALINATION,1987,62:117-136. |
| [8] | Potts D E;Ahlert R C;Wang S S .A critical review of fouling of reverse osmosis membranes[J].DESALINATION,1981,36:235-264. |
| [9] | Marshall A D;Munro P A;Tragardh G .The effect of protein fouling in microfiltration and ultrafiltration on permeate flux,protein retention and selectivity:A literature review[J].DESALINATION,1993,91:65-64. |
| [10] | Gekas V;Hallstr(o)m B .Mass transfer in the membrane concentration polarization layer under turbulent cross flow,I.Critical literature review and adaptation of existing sherwood correlations to membrane operations[J].Journal of Membrane Science,1987,30:153-170. |
| [11] | S S Sablani;M F A Goosen;R Al-Belushi;M Wilf .Concentration polarization in ultrafiltration and reverse osmosis: a critical review[J].Desalination: The International Journal on the Science and Technology of Desalting and Water Purification,2001(3):269-289. |
| [12] | W. RICHARD BOWEN;FRANK JENNER .THEORETICAL DESCRIPTIONS OF MEMBRANE FILTRATION OF COLLOIDS AND FINE PARTICLES: AN ASSESSMENT AND REVIEW[J].Advances in Colloid and Interface Science,1995(0):141-200. |
| [13] | Nikolova JD.;Islam MA. .Contribution of adsorbed layer resistance to the flux-decline in an ultrafiltration process[J].Journal of Membrane Science,1998(1):105-111. |
| [14] | Chen V.;Madaeni S.;Wenten IG.;Fane AG. .PARTICLE DEPOSITION DURING MEMBRANE FILTRATION OF COLLOIDS - TRANSITION BETWEEN CONCENTRATION POLARIZATION AND CAKE FORMATION[J].Journal of Membrane Science,1997(1):109-122. |
| [15] | Koltuniewicz A;Noworyta A .Dynamic properties of ultrafiltration systems in light of the surface renewal theory[J].Industrial and Engineering Chemistry Research,1994,33:1771-1779. |
| [16] | Porter M C .Concentration polarization with membrane ultrafiltration[J].Industrial and Engineering Chemistry Product Research and Development,1972,11(03):234-248. |
| [17] | Clifton M J;Abidine N;Aptel P et al.Growth of the polarization layer in ultrafiltration with hollow-fibre membranes[J].Journal of Membrane Science,1984,21:233-245. |
| [18] | M.M. Dal-Cin;F. McLellan;C.N. Striez;C.M. Tam;T.A. Tweddle;A. Kumar .Membrane performance with a pulp mill effluent: Relative contributions of fouling mechanisms[J].Journal of Membrane Science,1996(2):273-285. |
| [19] | Agashichev S P .Modelling concentration polarization phenomena for membrane channel with cylindrical geometry in an ultrafiltration process[J].Desalination,1998,119:159-168. |
| [20] | B.Tansel;W.Y.Bao;I.N.Tansel .Characterization of fouling kinetics in ultrafiltration systems by resistances in series model[J].Desalination,2000(1):7-14. |
| [21] | Song LF. .Flux decline in crossflow microfiltration and ultrafiltration: mechanisms and modeling of membrane fouling[J].Journal of Membrane Science,1998(2):183-200. |
| [22] | P. Bacchin;P. Aimar;V. Sanchez .Model for Colloidal Fouling of Membranes[J].AIChE Journal,1995(2):368-376. |
| [23] | Flora Joseph R V .Stotchastic approach to modeling surface fouling of ultrafiltration membranes via surface flurination[J].Journal of Membrane Science,1993,76(01):85-88. |
| [24] | H.K. Shon;S. Vigneswaran;In S. Kim;J. Cho;H.H. Ngo .Effect of pretreatment on the fouling of membranes: application in biologically treated sewage effluent[J].Journal of Membrane Science,2004(1/2):111-120. |
| [25] | Maartens A.;Jacobs EP.;Swart P. .UF of pulp and paper effluent: membrane fouling-prevention and cleaning[J].Journal of Membrane Science,2002(1):81-92. |
| [26] | 张国俊,刘忠洲.膜过程中膜清洗技术研究进展[J].水处理技术,2003(04):187-190. |
| [27] | 张国俊,刘忠洲.膜过程中超滤膜污染机制的研究及其防治技术进展[J].膜科学与技术,2001(04):39-45. |
| [28] | 张国俊 .超滤技术在印钞擦版废液处理回用中的应用——膜污染机理和清洗方法研究及全处理工艺开发[D].中国科学院生态环境研究中心,2002. |
| [29] | 邢卫红,童金忠,徐南平,时钧,王焕章,陈文艳,蔡旭新.微滤和超滤过程中浓差极化和膜污染控制方法研究[J].化工进展,2000(01):44-48,56. |
| [30] | 董秉直,夏丽华,陈艳,高乃云,范瑾初.混凝处理防止膜污染的作用与机理[J].环境科学学报,2005(04):530-534. |
| [31] | 伍艳辉,王志,何菲,王世昌.膜与蛋白质溶液的相互作用及膜污染机制的能谱研究[J].化工学报,2001(11):1026-1029. |
| [32] | Vilker V L;Colton C K;Smith K A .Concentration polarization in protein ultrafiltration Part 1:An optical shadowgraph technique for measuring concentration profiles near a solution-membrane interface[J].AICHE Journal,1981,27:632-637. |
| [33] | Vilker V L;Colton C K;Smith K A .Concentration polarization in protein ultrafiltration Part 2:theoretical and experimental study of albumin ultrafiltered in an unstirred batch cell[J].AICHE Journal,1981,27:637-645. |
| [34] | Chan R;Chen V .Characterization of protein fouling on membranes: opportunities and challenges[J].Journal of Membrane Science,2004(1/2):169-188. |
| [35] | Chan R;Chen V;Bucknall M P .Quantitative analysis of membrane fouling by protein mixtures using MALDI-MS[J].Biotechnology and Bioengineering,2004,85(02):190-201. |
| [36] | Ethier C R;Lin D C .Refractometric measurement of polarized layer structure:studies of hyaluronic acid ultrafiltration[J].Journal of Membrane Science,1992,68:249-261. |
| [37] | Gowman LM.;Ethier CR. .CONCENTRATION AND CONCENTRATION GRADIENT MEASUREMENTS IN AN ULTRAFILTRATION CONCENTRATION POLARIZATION LAYER .1. A LASER-BASED REFRACTOMETRIC EXPERIMENTAL TECHNIQUE[J].Journal of Membrane Science,1997(1/2):95-105. |
| [38] | Gowman LM.;Ethier CR. .CONCENTRATION AND CONCENTRATION GRADIENT MEASUREMENTS IN AN ULTRAFILTRATION CONCENTRATION POLARIZATION LAYER .2. APPLICATION TO HYALURONAN[J].Journal of Membrane Science,1997(1/2):107-123. |
| [39] | Yao S.;Fane AG.;Pope JM.;Costello M. .NON-INVASIVE OBSERVATION OF FLOW PROFILES AND POLARISATION LAYERS IN HOLLOW FIBRE MEMBRANE FILTRATION MODULES USING NMR MICRO-IMAGING[J].Journal of Membrane Science,1995(3):207-216. |
| [40] | J.M. Pope;S. Yao;A.G. Fane .Quantitative measurements of the concentration polarisation layer thickness in membrane filtration of oil-water emulsions using NMR micro-imaging[J].Journal of Membrane Science,1996(2):247-257. |
| [41] | Yao S;Fane AG;Pope JM .An investigation of the fluidity of concentration polarisation layers in crossflow membrane filtration of an oil-water emulsion using chemical shift selective flow imaging[J].Magnetic resonance imaging: An International journal of basic research and clinical applications,1997(2):235-242. |
| [42] | Airey D.;Wu J.;Chen V.;Fane AG.;Pope JM.;Yao S. .An investigation of concentration polarization phenomena in membrane filtration of colloidal silica suspensions by NMR micro-imaging[J].Journal of Membrane Science,1998(2):145-158. |
| [43] | McDonogh R M;Bauser H;Stroh N et al.Separation efficiency of membrane in biotechnology:an experimental and mathematical study of flux control[J].Chemical Engineering Science,1992,47(01):271-279. |
| [44] | Mcdonogh RM.;Stroh N.;Grauschopf U.;Bauser H. .EXPERIMENTAL IN SITU MEASUREMENT OF CONCENTRATION POLARISATION DURING ULTRA- AND MICRO-FILTRATION OF BOVINE SERUM ALBUMIN AND DEXTRAN BLUE SOLUTIONS[J].Journal of Membrane Science,1995(1/2):51-63. |
| [45] | Li H.;Coster HGL.;Vigneswaran S.;Fane AG. .Direct observation of particle deposition on the membrane surface during crossflow microfiltration[J].Journal of Membrane Science,1998(1):83-97. |
| [46] | Kang S.A novel quantification method for the initial deposition of microorganisms onto a membrane surface[J].Water Science and Technology |
| [47] | Wendy D.Mores;Robert H.Davis .Direct visual observation of yeast deposition and removal during microfiltration[J].Journal of Membrane Science,2001(2):217-230. |
| [48] | Altmann J;Ripperger S .Particle deposition and layer formation at the crossflow microfiltration[J].Journal of Membrane Science,1997,124:119-128. |
| [49] | Hamachi M.;Mietton-Peuchot M. .Experimental investigations of cake characteristics in crossflow microfiltration[J].Chemical Engineering Science,1999(18):4023-4030. |
| [50] | M.Hamachi;M.Mietton-Peuchot .Cake Thickness measurement with an optical laser sensor[J].Chemical Engineering Research & Design: Transactions of the Institution of Chemical Engineers,2001(A2):151-155. |
| [51] | Kuo-Lun Tung;Sherjing Wang;Wei-Ming Lu .In situ measurement of cake thickness distribution by a photointerrupt sensor[J].Journal of Membrane Science,2001(1):57-67. |
| [52] | Anurag P.Mairal;Alan R. Greenberg;William B. Krantz .Real-time measurement of inorganic fouling of RO desalination membranes using ultrasonic time-domain reflectometry[J].Journal of Membrane Science,1999(1/2):185-196. |
| [53] | Li J;Sanderson R D .In situ measurement of particle deposition and its removal in microfiltration by ultrasonic time-domain reflectometry[J].Desalination,2002,146:169-175. |
| [54] | Li Jianxin;Sanderson R D;Cahi G Y et al.Development of an ultrasonic technique for in situ investigating the properties of deposited protein during crossfloe uitrafiltration[J].Journal of Colloid and Interface Science,2005,284:228-238. |
| [55] | Li Jianxin;Hallbauer D K;Sanderson R D .Direct monitoring of membrane fouling and cleanin during ultrafiltration using a non-invasive ultrasonic technique[J].Journal of Membrane Science,2003,215:33-52. |
| [56] | Chilcott TC.;Chan M.;Gaedt L.;Nantawisarakul T.;Fane AG.;Coster HGL. .Electrical impedance spectroscopy characterisation of conducting membranes I. Theory[J].Journal of Membrane Science,2002(2):153-167. |
| [57] | Gaedt L.;Chilcott TC.;Chan M.;Nantawisarakul T.;Fane AG.;Coster HGL. .Electrical impedance spectroscopy characterisation of conducting membranes II. Experimental[J].Journal of Membrane Science,2002(2):169-180. |
| [58] | Su TJ.;Cui ZF.;Thomas RK.;Heenan RK.;Lu JR. .Application of small angle neutron scattering to the in situ study of protein fouling on ceramic membranes[J].Langmuir: The ACS Journal of Surfaces and Colloids,1998(19):5517-5520. |
| [59] | Su T.J;Lu J.R .Identification of the location of protein fouling on ceramic membranes under dynamic filtration conditions[J].Journal of Membrane Science,1999(2):265-275. |
| [60] | Su T J;Lu J R;Cui Z R et al.Fouling of ceramic membranes by albumins under dynamic filtration conditions[J].Journal of Membrane Science,2000,173:167-178. |
| [61] | Frederic Pignon;Albert Magnin;Jean-Michel Piau .Structural characterisation of deposits formed during frontal filtration[J].Journal of Membrane Science,2000(2):189-204. |
| [62] | Oppnheim Fredrick S .Protein ultrafiltration membrane fouling as examined paragnetic resonance spectroscope[Z].DAI-B 57/07,1997. |
| [63] | Khulbe KC.;Singh S.;Lamarche G.;Noh SH.;Matsuura T. .Study on fouling of ultrafiltration membrane by electron spin resonance[J].Journal of Membrane Science,2000(2):263-273. |
| [64] | 赵广英 .饮水净化中反渗透膜过程的预处理和污染的研究[D].清华大学,2000. |
| [65] | Guojun Zhang;Zhongzhou Liu .Membrane fouling and cleaning in ultrafiltration of wastewater from banknote printing works[J].Journal of Membrane Science,2003(2):235-249. |
| [66] | Butt F H;Rahman F;Baduruthamal U .Characteriszation of foulants by autopsy of RO desalination membranes[J].DESALINATION,1997,114:51-64. |
| [67] | Park N;Kwon B;Cho Jaeweon et al.Characteriztions of the colloid and microbial organic matters with respect to membrane foulants[J].Journal of Membrane Science,2006,275:29-36. |
| [68] | Kwon B;Cho J;Park N;Pellegrino J .Organic nanocolloid fouling in UF membranes[J].Journal of Membrane Science,2006(1/2):209-219. |
| [69] | Ghosh R. .Study of membrane fouling by BSA using pulsed injection technique[J].Journal of Membrane Science,2002(1):115-123. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%