温度场计算的准确性对气冷涡轮的设计影响极大.实际的气冷涡轮在运行状态下,存在多种物理现象:冷气带来的燃气组分变化、湍流、转捩、温度边界层的发展变化、热辐射等.而在数值计算中,计算结果也要受到网格质量的影响.采用自编程序、商业CFD软件对某两级气冷涡轮、C3X以及MARK Ⅱ叶片进行计算,分别描述冷气组分变化、计算网格、湍流模型以及转捩温度场模拟精度的影响;同时定性分析温度边界层复合性质与辐射换热对温度计算的影响.得出在气热耦合计算中,考虑上述因素的影响是很有必要的.
参考文献
| [1] | 曹玉璋;陶智.航空发动机传热学[M].北京:北京航空航天大学出版社,2005 |
| [2] | York W D;Leylek J H.Three-Dimensional Conjugate Heat Transfer Simulation of an Internally-Cooled Gas Turbine Vane[A].,2003 |
| [3] | Facchini B;Magi A;Greco ASD.Conjugate Heat Transfer Simulation of a Radially Cooled Gas Trubine Vane[A].,2004 |
| [4] | Heidmann J D;Kassab A J;Steinthorsson E.Conjugate Heat Transfer Effects on a Realistic Film-Cooled Turbine Vane[A].,2003 |
| [5] | Kusterer K;Bohn D;Sugimoto T.Improvement of a File-Cooled Blades by Application of the Conjugate Heat Transfer Technique[A].,2005 |
| [6] | Hylton LD;Milhec M S;Turner E R et al.Analytical and Experimental Evaluation of the Heat Transfer Distribution Over the Surface of Turbine Vanes[NASA-CR-168015][R].,1983. |
| [7] | 李海滨,黄家骅,冯国泰,杨科.涡轮叶栅冷气掺混计算的数学模型与方法[J].航空发动机,2001(01):40-42. |
| [8] | 王强,颜培刚,王松涛,冯国泰,王仲奇.考虑冷气组分扩散的气冷涡轮流场的数值模拟[J].工程热物理学报,2007(z1):101-104. |
| [9] | Abu-Gharmam B J;Shaw R .Natural Transition of Boundary Layers:The Effects of Turbulence,Pressure Gradient,and Flow History[J].Journal of Mechanical Engineering Science,1980,22(05):213-228. |
| [10] | Dhawan S;Narasimha R .Some Properties of Boundary Layer during the Transition from Laminar to Turbulent Flow Motion[J].Journal of Fluid Mechanics,1958,3:418-438. |
| [11] | Menter F R;Langtry R B;Likki S R et al.A Correlation-Based Transition Using Local Variables Part I-Model Formulation[ASME Paper 2004-GT-53452][R].,2004. |
| [12] | Kays W M .Turbulent Prandtl Number-where Are We?[J].International Journal Heat Mass and Transfer,1994,37(05):284-295. |
| [13] | Kim J;Moin P.Transport of Passive Scalars in a Turbulent Channel Flow[A].Berlin,Germany,1989:85-96. |
| [14] | Reynolds A J .The Prediction of Turbulent Prandtl and Schmidt Numbers[J].International Journal of Heat and Mass Transfer,1975,18:1055-1069. |
| [15] | Nagano Y;Kim C .A Two-Equation Model for Heat Transfer in Wall Turbulent Shear Flows[J].Journal of Heat Transfer,1988,110:583-589. |
| [16] | Hwang C B;Lin C A .A Low Reynolds Number Two-Equation κθ-εθ Model to Predict Thermal Fields[J].International Journal of Heat and Mass Transfer,1999,42:3217-3230. |
| [17] | Kawamura H;Kurihara Y .Modeling of Turbulent Scalar Transport in Homogeneous Turbulence[J].International Journal of Heat and Mass Transfer,2000,43:1935-1945. |
| [18] | Jones W P;Musonge P .Closure of the Reynolds Stress and Scalar Flux Equation[J].Physics of Fluids,1988,31(12):3589-3604. |
| [19] | Dong YH.;Lu XY.;Zhuang LX. .An investigation of the Prandtl number effect on turbulent heat transfer in channel flows by large eddy simulation[J].Acta Mechanica,2002(1/4):39-51. |
| [20] | Kim J;Moin P.Transport of Passive Scalars in a Turbulent Channel Flow[A].New York:springer-verlag,1989:85-96. |
| [21] | Kong H.;Lee JS.;Choi H. .Direct numerical simulation of turbulent thermal boundary layers[J].Physics of fluids,2000(10):2555-2568. |
| [22] | 贺志宏,谈和平,刘林华,冯国泰,阮立明.发动机叶片流道内辐射换热的数值计算[J].推进技术,2001(01):65-68,88. |
| [23] | 王平阳,谈和平,刘林华,罗剑峰.涡轮发动机高温隔热涂层内的传热研究[J].航空动力学报,2000(03):268-273. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%