采用共沉淀法制备新型的含Al、Ca复合除氟剂。结果表明：在含100 g/L Zn2+、160 g/L H2SO4和450 mg/L F?的硫酸锌电解液中复合除氟剂除氟的最优条件为：pH=3，t=90 min，w=4 g/L，θ=25℃。此时，F?浓度可降低至20mg/L以下，除氟率可达96%，除氟剂吸附容量达108 mg/g。结果表明：仅当Cl?浓度大于800 mg/L时，复合除氟剂的除氟率降至93%。SO42?和 Zn2+的浓度对复合除氟剂的除氟效果没有影响，除氟率一直保持在96%左右，除氟过程锌损失率小于5%。吸附平衡曲线结果表明：该型复合除氟剂的吸附过程符合Langmuir 单层吸附模型，最大理论吸附容量143.3 mg/g。
s:A novel Al, Ca-containning composite defluoridation agentwassynthetized by co-precipitation method.The results show that the optimum conditions to defluoridation from zinc sulfate solution (ρ(F?)=450 mg/L,ρ(H2SO4)=160 g/L,ρ(Zn)=60 g/L) are as follows: pH=3,t=90 min,w=4 g/L,θ=25℃. The finalρ(F?)is below 20 mg/L, the fluoride ions removal efficiencyisabout 96%, and the adsorption capacityis108 mg/g. The results show that only when theρ(Cl?) is above 800 mg/L,thefluoride removal efficiency slightly descendsto 93%. Theρ(SO42?)andρ(Zn2+)show no influence on the removal efficiency, zinc lossrateis less than 5% during the defluoridation process. The equilibrium isotherm reasonablyfitsthe Langmuir isotherm model, and the maximum monolayer sorption capacityis143.3 mg/g.
参考文献
| [1] | Zhong, Xiaocong;Yu, Xiaoying;Jiang, Liangxing;Lv, Xiaojun;Liu, Fangyang;Lai, Yanqing;Li, Jie.Influence of Fluoride Ion on the Performance of Pb-Ag Anode During Long-Term Galvanostatic Electrolysis[J].JOM,20159(9):2022-2027. |
| [2] | 苏莎;陈海清.湿法炼锌中氟氯去除方法的研究[J].湖南有色金属,2013(1):40-43. |
| [3] | 张元福;陈家蓉.针铁矿法从氧化锌烟尘浸出液中除氟氯的研究[J].湿法冶金,1999(02):36. |
| [4] | 万挺;梅晶.硫酸锌溶液中混凝沉淀降氟实验研究[J].广州化工,2013(24):84-85,117. |
| [5] | 卢建杭;刘维屏;郑巍.铝盐混凝去除氟离子的作用机理探讨[J].环境科学学报,2000(6):709-713. |
| [6] | 刘国标;单丽梅;马荣峰.镁盐法脱除氧化锌烟尘浸出液中的氟[J].湿法冶金,2011(1):64-67. |
| [7] | 唐道文;毛小浩;黄碧芳;赵平原.硫酸锌溶液中氟氯净化的实验研究[J].贵州工业大学学报(自然科学版),2004(3):15-17,22. |
| [8] | 姜科;周康根;李程文.粒径对CaF2沉淀-溶解平衡的影响[J].中国有色金属学报,2011(12):3195-3201. |
| [9] | 谢虹;贾文波;吴志刚.活性氧化铝除氟剂的除氟性能研究[J].华中科技大学学报（医学版）,2005(5):644-646. |
| [10] | 胡安生;张旭;沈庆峰;张积锴;孙敬会.湿法炼锌硫酸盐溶液中除氟试验研究[J].矿冶工程,2015(4):101-103. |
| [11] | 单丽梅;李志宏;王泽忠;刘国标.铈盐法脱除氧化锌烟尘净化液中的F-[J].湿法冶金,2014(2):141-144. |
| [12] | 胡家朋;吴代赦;饶瑞晔;陈喆;赖文亮.Mn-Al双氢氧化物对氟离子的吸附热力学和动力学研究[J].硅酸盐通报,2015(4):1071-1077. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%