采用溶胶凝胶法在不同pH值和煅烧温度条件下制备了M型纳米钡铁氧体样品,利用X射线衍射、场发射扫描电镜以及振动样品磁强计研究了溶液pH值和煅烧温度对纳米钡铁氧体的微结构和磁性能的影响.实验结果表明:溶液pH值及煅烧温度对钡铁氧体的相结构和磁性能都有很大影响.当溶液pH值在3以上时,有利于BaFe12O19相的形成,纳米钡铁氧体的晶粒尺寸约50 nm,饱和磁化强度Ms和矫顽力Hc在pH=7时达到最高.对于pH=7的样品,在700℃左右开始有BaFe12O19相形成,同时伴有较多量的α-Fe2O3和少量的BaFe2O4与BaCO3杂相.随着温度的升高,BaFe12O19主相不断形成积累,杂相逐渐减少,当煅烧温度为800℃时,样品基本上为纯BaFe12O19相,经900℃热处理后样品磁性能最佳:饱和磁化强度达到Ms=61.6(A·m2)/kg,矫顽力为Hc=4.56×105A/m.
参考文献
| [1] | Imamura M;Ito Y;Fujiki M et al.[J].IEEE Transactions on Magnetics,1986,22:1185. |
| [2] | Sui X;Kryder M H .[J].Applied Physics Letters,1993,63:1582. |
| [3] | Pankov V V;Pernet M;Germi P et al.[J].Journal of Magnetism and Magnetic Materials,1993,120:69. |
| [4] | Licci F;Besagni T .[J].IEEE Transactions on Magnetics,1984,MAG-20:1639. |
| [5] | Pillai V;Kumar P;Shah D O .[J].Journal of Magnetism and Magnetic Materials,1992,116:L299. |
| [6] | Kuz'mitcheva T.G.;Ol'khovik L.P. .Synthesis and properties of fine Ba-ferrite powders[J].IEEE Transactions on Magnetics,1995(1):800-803. |
| [7] | Kamishima K;Ito C;Kakizaki K;Hiratsuka N;Shirahata T;Imakubo T .Improvement of initial permeability for Z-type ferrite by Ti and Zn substitution[J].Journal of Magnetism and Magnetic Materials,2007(1):228-233. |
| [8] | 郭兴忠,杨辉,王建武.SiC/YAG复合粉体的烧结特性与力学性能[J].稀有金属材料与工程,2004(z1):58-60. |
| [9] | Kan H H;Zhang D H;Yang H et al.[J].Journal of Materials Science Letters,1997,16(03):190. |
| [10] | 郭兴忠,杨辉,王建武.溶胶-凝胶法制备SiC/YAG复合粉体[J].稀有金属材料与工程,2004(z1):55-57. |
| [11] | Guo XZ;Yang H;Cao M .Nucleation and crystallization behavior of Li2O-Al2O3-SiO2 system glass-ceramic containing little fluorine and no-fluorine[J].Journal of Non-Crystalline Solids: A Journal Devoted to Oxide, Halide, Chalcogenide and Metallic Glasses, Amorphous Semiconductors, Non-Crystalline Films, Glass-Ceramics and Glassy Composites,2005(24/25):2133-2137. |
| [12] | Mali A;Ataie A .[J].Journal of Alloys and Compounds,2005,399:245. |
| [13] | Yu HF;Lin HY .Preparation and thermal behavior of aerosol-derived BaFe12O19 nanoparticles[J].Journal of Magnetism and Magnetic Materials,2004(2/3):190-198. |
| [14] | Xu G Q;Ma H L;Zhong M J et al.[J].Journal of Magnetism and Magnetic Materials,2006,301:383. |
| [15] | Paul, KB .Magnetic and structural properties of Ba M-type ferrite-composite powders[J].Physica. B, Condensed Matter,2007(1/2):337-343. |
| [16] | Chikazumi S;葛世慧.铁磁性物理[M].兰州:兰州大学出版社,2002:169. |
| [17] | Kerschl P.;Grossinger R.;Kussbach C.;Sato-Turtelli R.;Muller KH. Schultz L. .Magnetic properties of nanocrystalline barium ferrite at high temperatures[J].Journal of Magnetism and Magnetic Materials,2002(2):1468-1470. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%