针对不同均匀化处理方式会引起合金微观组织和电化学性能变化现象,采用电子探针(EPMA)、动电位极化及恒电流极化等方法研究不同热处理(水淬、空冷、炉冷)方式对Al-Zn-In合金的微观组织和合金在3%NaCl溶液中的开路电位、工作电位、腐蚀形貌和电流效率等电化学性能的影响.结果表明:510℃,10 h的均匀化处理使晶界偏析减少,抑制析氢自腐蚀和晶粒脱落,提高电流效率,但对阳极开路电位、工作电位及溶解行为的影响并不明显,且水淬处理试样的电流效率最高.
参考文献
| [1] | GB/T 4948-2002.GB/T 4948-2002.铝-锌-铟系合金牺牲阳极[S]. |
| [2] | Reboul M C;Gimenez P H;Ramaeu J J .Proposed activation mechanism for Al anodes[J].Corrosion,1984,40(07):366-371. |
| [3] | Breslin C B;Carroll W M .Activation of aluminum by activator elements[J].Corrosion Science,1993,35(01):197-203. |
| [4] | Gurrappa I .The surface free energy and anode efficiency of aluminium alloys[J].Corrosion Prevention & Control,1993,40(10):111-114. |
| [5] | 廖海星,齐公台,喻克雄.固溶处理对含RE铝牺牲阳极组织与性能的影响[J].材料热处理学报,2004(03):54-56. |
| [6] | Bessone J B;Flamini D O;Saidman S B .Comprehensive model for the activation mechanism of Al-Zn alloys produced by indium[J].Corrosion Science,2005,47(01):95-105. |
| [7] | 齐公台,郭稚弧,魏伯康,林汉同.固溶处理对Al-Zn-In-Sn-Mg阳极组织与电化学性能的影响[J].金属热处理学报,2000(04):68-72. |
| [8] | S R Ashok;A Venkataramani;G T Parthiban .Performance of aluminium anodes under heat treatment[J].Corrosion Prevention & Control,2002(2):60-63. |
| [9] | Pautasso J P;Guyader H L;Debout V.Low voltage cathodic protection for high strength steels (part 1):Definition of a new aluminium galvanic anode material[A].Huston:NACE,1998:725. |
| [10] | Salinas DR;Bessone JB;Garcia SG .Influence of alloying elements and microstructure on aluminium sacrificial anode performance: case of Al-Zn[J].Journal of Applied Electrochemistry,1999(9):1063-1071. |
| [11] | Kulkarni A G;Gurrappa I .Effect of magnesium addition on surface free energy and anode capacity of indium activated aluminium alloys[J].British Corrosion Journal,1993,28(01):67-70. |
| [12] | 许刚.纯铝在NaCl溶液中活化溶解时电化学行为研究[J].腐蚀科学与防护技术,1998(06):321. |
| [13] | 毛卫民,陈垒,萨丽曼,余永宁,李云峰.晶界对低压电解电容器铝箔腐蚀结构的影响[J].中国有色金属学报,2004(01):1-5. |
| [14] | Buchheit RG. .A COMPILATION OF CORROSION POTENTIALS REPORTED FOR INTERMETALLIC PHASES IN ALUMINUM ALLOYS [Review][J].Journal of the Electrochemical Society,1995(11):3994-3996. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%