The thermomechanical fatigue behaviour of different high temperature alloys has been investigated and is under investigation respectively. The creep-fatigue behaviour of heat resistant steels was investigated by long-term service-type strain cycling tests simulating thermomechanical fatigue (TMF-) loading conditions at the heated surface of e.g. turbine rotors. Single-stage as well as three-stage cycles leads to similar results at the application of the damage accumulation rule. Life prediction which simulates typical combinations of cold starts, warm starts and hot starts has been established successfully for isothermal service-type loading and will be exceeded for thermomechanical loading. Long-term thermomechanical fatigue testing of Thermal Barrier Coating systems show typical delamination damage. An advanced TMF cruciform testing system enables complex multiaxial loading.
参考文献
| [1] | G Harkegard;ed.L.H.Larsson.High Temperature Structual Design, ESIS12[M].Mechanical Eng.Pub.,London,1992:21. |
| [2] | A Scholz;J.Granacher;C.Berger;eds.K.T.Rie and P.D.Portella.Proc. of the Fourth Int. Conf. on Low Cycle Fatigue and Elasto-Plastic Behaviour of Materials[C].Garmisch-Parten-Kirchen,1998:741. |
| [3] | A Scholz;H.Haase;nd C.Berger;A.F.Blom.Fatigue 2002, Proc. of the Eighth Int. Fatigue Congress[J].Vol 5/5 Stockholm,2002:3133. |
| [4] | J Granacher;A. Scholz;ed. K.T. Rie.Proc. of the Third Int. Conf. "Low Cycle Fatigue and Elasto-Plastic Behaviour of Materials"[J].Elsevier Appl Sc London,1992:235. |
| [5] | M Schwienheer;A.Scholz;H.Haase;C.Berger.Fifth Int. Conf. on Low Cycle Fatigue, LCF 5[M].DVM, Berlin, 09-10 September,2003 |
| [6] | A Scholz;H.Kirchner;P.Hortig;J.Granacher and C.Berger .Materials Week[Z].Munchen),2000. |
| [7] | A Scholz;B.Heinecke;A.Schmidt;C.Berger.Fifth Int. Conf. On Low Cycle Fatigue, LCF 5[M].DVM,Berlin,09-10,September,2003 |
| [8] | C Berger;B. Heinecke;A. Scholz;W.A. Kayser .Proc. of Int. Turbomat Symp., Advanced Thermal Barrier Coating and Titanium Aluminides for Gas Turbines[Z].DLR German Aero Space Center, Bonn,2002. |
| [9] | A Scholz;A.Samir;C.Berger;eds.C.M.Sonsino,H.Zenner and P.D.Portella.Proc. of 7th Int. Conf. on Biaxial and Multiaxial Fatigue &Fracture[C].Berlin,2004:555. |
| [10] | Untersuchung des Krieehermiidungsverhaltens von Hochtemperaturwerkstoffen unter anisothermer biaxialer Dehnwechelbeanspruchung[S].DFG-Project BE 1890, 16-1, IfW TU Darmstadt,2000. |
| [11] | M Ohnami;M. Sakane;S. Mukai.Proc. of the Fourth Int. Conf. on Low Cycle Fatigue and Elasto-Plastic Behaviour of Materials[C].Garmisch-Partenkirchen,1998:229. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%