采用循环伏安(CV)和恒电位阶跃(CA)等电化学技术,研究金刚石粉体对Ni电结晶形核/生长的影响,并通过扫描电镜观察复合镀层的表面形貌.结果表明:在Ni?金刚石复合镀液中,金刚石粉体吸附在阴极表面,对阴极产生屏蔽作用,Ni2+的有效放电面积减小,阻碍电荷转移,使复合镀液在循环伏安曲线中的还原电流降低;金刚石粉体缩短了Ni电结晶的形核驰豫时间(tmax),形核过电位正移,促进Ni电结晶形核;电镀时间越长,金刚石复合量越小,镀层表面越粗糙;Ni?金刚石复合镀液和纯Ni镀液的Ni电结晶形核可能为多晶沉积.
@@@@The effect of diamond powder on the nickel electrocrystallization nucleation/growth behavior was investigated by electrochemical techniques, such as cyclic voltammetry(CV) method and chronoamperometry method (CA), and the surface morphologies of composite coatings were observed by SEM. The results show that, in Ni-diamond electroplating solutions, diamond powder absorbed on the cathode surface decreases the effective area of Ni ion discharge and hinders the process of charge transfer because of the shielded cathode surface, which corresponds to much lower reduction current of CV curve? diamond powder shortens the nucleation relaxation time tmax of Ni electrocrystallization, the nucleation potential turns to positive direction, and Ni electrocrystallization is stimulated?the diamond powder content in Ni-diamond composite coatings decreases with the increase of electroplating time, which makes the surface of coatings coarsen? both Ni-diamond electroplating solution and pure Ni electroplating solution may follow the polycrystalline deposition mechanism.
参考文献
| [1] | 郭鹤桐;张三元.复合电镀技术[M].北京:化学工业出版社,2007:4-119. |
| [2] | 杨绮琴.应用电化学[M].广州:中山大学出版社,2005:162. |
| [3] | A.Sahari;A.Azizi;G.Schmerber;M.Abes;J.P.Bucher .Electrochemical nucleation and growth of Co and CoFe alloys on Pt/Si substrates[J].Catalysis Today,2006(3/4):257-262. |
| [4] | Min Gu .Initial stages of the electrocrystallization of Co-Cu alloys on GCE from the Co rich electrolytes[J].Electrochimica Acta,2007(13):4443-4448. |
| [5] | Darko Grujicic;Batric Pesic .Electrochemical and AFM study of cobalt nucleation mechanisms on glassy carbon from ammonium sulfate solutions[J].Electrochimica Acta,2004(26):4719-4732. |
| [6] | LI Jing-feng,ZHANG Zhao,YIN Jun-ying,YU Geng-hua,CAI Chao,ZHANG Jian-qing.Electrodeposition behavior of nanocrystalline CoNiFe soft magnetic thin film[J].中国有色金属学会会刊（英文版）,2006(03):659-665. |
| [7] | 谭澄宇,刘宇,胡炜,崔航.Ni-SiC电结晶沉积层的阻抗谱及SiC颗粒对Ni沉积的影响[J].材料保护,2009(05):11-16. |
| [8] | TU Wei-yi,XU Bin-shi,DONG Shi-yun,JIANG Bin,DU Ling-zhong.Effect of n-Al2O3 on electrochemical nucleation and chemical binding interaction in nickel electrodeposition[J].中国有色金属学会会刊（英文版）,2005(04):889-896. |
| [9] | Nowak P.;Kaisheva M.;Fransaer J.;Celis JP.;Stoinov Z.;Socha RP. .Electrochemical investigation of the codeposition of SiC and SiO2 particles with nickel[J].Journal of Applied Electrochemistry,2000(4):429-437. |
| [10] | 王立平,高燕,薛群基,刘惠文,徐洮.纳米金刚石对电沉积镍基复合镀层微观结构及抗磨性能的影响[J].摩擦学学报,2004(06):488-492. |
| [11] | 杜楠,周海飞,赵晴,廖强.Ni-金刚石复合电沉积的界面作用力及其对复合量的影响[J].材料工程,2008(02):23-26,30. |
| [12] | 曹学功.镍-金刚石复合镀层耐磨性能研究[J].华侨大学学报（自然科学版）,2000(02):141-143. |
| [13] | LEEA E C;CHOI J W .A study on the mechanism of formation of electrocodeposited Ni-diamond coatings[J].Surface and Coatings Technology,2001,148(2/3):234-240. |
| [14] | 赵旭山 .Ni-SiC复合沉积电极过程动力学及镀层电化学腐蚀行为研究[D].中南大学,2008. |
| [15] | Lee HK;Lee HY;Jeon JM .Codeposition of micro- and nano-sized SiC particles in the nickel matrix composite coatings obtained by electroplating[J].Surface & Coatings Technology,2007(26):4711-4717. |
| [16] | 楚广,刘生长.新型Ni-Cu复合镀层的制备[J].中南大学学报（自然科学版）,2007(03):474-479. |
| [17] | ETERSSON I;AHLBERG E .Kinetics of the electrodeposition of Pb circle divide Sn alloys(Part I):At glassy carbon electrodes[J].Journal of Electroanalytical Chemistry,2000,485:166-177. |
| [18] | 曹经倩.Cr(VI)对镍沉淀的影响[J].南昌航空工业学院学报,1994(01):14-19. |
| [19] | 赵旭山,谭澄宇,陈文敬,刘宇,李劲风,郑子樵.Ni-SiC复合镀层电结晶初期动力学分析[J].中国有色金属学报,2008(05):823-828. |
| [20] | GREEF R;PEAT R;PETER L M;PLETCHER L M,PLETCGER D,ROBINSON J.柳厚田,徐品弟.电化学中的仪器方法[M].上海:复旦大学出版社,1992:310. |
| [21] | SCHARIFKER B;HILLS G .Theoretical and experimental studies of multiple nucleation[J].Electrochimica Acta,1983,28(07):879-889. |
| [22] | AFSHR A;DOLATI A G;GHORBANI M .Electrochemical characterization of the Ni-Fe alloy electrodeposition from chloride-citrate-glycolic acid solution[J].Materials Chemistry and Physics,2002,77(02):352-358. |
| [23] | 谭澄宇,崔航,胡炜,刘宇,郑子樵.纳米-Al_2O_3颗粒对镍电结晶初期阶段的影响[J].稀有金属材料与工程,2010(01):10-16. |
| [24] | Darko Grujicic;Batric Pesic .Electrodeposition of copper: the nucleation mechanisms[J].Electrochimica Acta,2002(18):2901-2912. |
| [25] | 刘宇,谭澄宇,贾志强,胡炜.铜离子对镍在玻碳电极上电结晶行为的影响[J].中南大学学报（自然科学版）,2010(01):144-149. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%