采用化学水浴法在玻璃上制备了太阳能电池中的ZnS缓冲层,采用SEM、EDS、XRD和nkd-分光光度计等手段研究了水浴温度对ZnS薄膜的表面形貌、结构和光学性能的影响.结果表明,升高温度不能明显改变薄膜的结晶性、形貌和沉积生长方式.能否成膜与温度的关系也不大,但成膜速率对温度的依赖性较大.随温度的升高,薄膜的透过率先减小后增大,反射率则先增大后减小.对同一试样而言,透过率和反射率对应较好.当温度为70℃时,可制得禁带宽度为3.83eV、符合化学计量比、平整的非晶ZnS薄膜.
ZnS thin films are prepared by chemical bath deposition on common glass substrates at different deposited temperature.In order to investigate the morphological,structural and optical properties of ZnS thin films have been investigated at different deposited temperature by SEM,EDS,XRD and nkd-spectrophotometer.Results show that with the increase of deposition temperature,the crystallinity,morphology and growth mode can not be improved evidently.Forming film or not is not dependence on the temperature.But the deposition rate of ZnS thin films has to depend on deposition temperature strongly.The transmission decreases firstly,increase finally,the reflectivity is inverse relationship with the temperature increasing.For the same sample,the transmission and reflectivity correspond well each other.When deposition temperature is 70℃,ZnS thin film is smooth and amorphous,near to stoichiometric proportion,3.83eV of band gap.
参考文献
| [1] | Yoshikawa A;Yamaga S;Tanaka K et al.Growth of lowresistivity high-quality ZnSe,ZnS films by low-pressure metalorganic chemical vapor deposition[J].Journal of Crystal Growth,1985,72(1-2):13. |
| [2] | Yokoyama M;Kashiro K;Ohta S .Molecular beam epitaxial growth of ZnS on a (100)-oriented Si substrate[J].Journal of Crystal Growth,1987,81(1-4):73. |
| [3] | Shao LX.;Chang KH.;Hwang HL. .Zinc sulfide thin films deposited by RF reactive sputtering for photovoltaic applications[J].Applied Surface Science: A Journal Devoted to the Properties of Interfaces in Relation to the Synthesis and Behaviour of Materials,2003(0):305-310. |
| [4] | S. Yano;R. Schroeder;B. Ullrich;H. Sakai .Absorption and photocurrent properties of thin ZnS films formed by pulsed-laser deposition on quartz[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2003(2):273-276. |
| [5] | Oikkonen M;Blomberg M;Tuomi T et al.X-ray diffraction study of microstructure in ZnS thin films grown from zinc acetate by atomic layer epitaxy[J].Thin Solid Films,1985,124(3-4): 1317. |
| [6] | Contreras M A;Nakada T;Hongo M.Proceedings 3rd world conference of photovoltaic energy conversion,osaka,Japan[M].New York:IEEE Press,2003:1570. |
| [7] | Kundu S;Olsen L C .Chemical bath deposited zinc sulfide buffer layers for copper indium gallium sulfur-selenide solar cells and device analysis[J].Thin Solid Films,2005,471:298. |
| [8] | Tokio Nakada;Masashi Hongo;Eiji Hayashi .Band offset of high efficiency CBD-ZnS/CIGS thin film solar cells[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2003(5):242-248. |
| [9] | Ibanga EJ.;Le Luyer C.;Mugnier J. .Zinc oxide waveguide produced by thermal oxidation of chemical bath deposited zinc sulphide thin films[J].Materials Chemistry and Physics,2003(2):490-495. |
| [10] | Gode F;Gumus C;Zor M .Investigations on the physical properties of the polycrystalline ZnS thin films deposited by the chemical bath deposition method[J].Journal of Crystal Growth,2007(1):136-141. |
| [11] | Poulomi Roy;Jyoti R Ota;Suneel Kumar Srivastava .Crystalline ZnS thin films by chemical bath deposition method and its characterization[J].Thin Solid Films,2006,515:1912. |
| [12] | Ennaoui A.;Eisele W.;Lux-Steiner M.;Niesen TP.;Karg E. .Highly efficient Cu(Ga,In)(S,Se)(2) thin film solar cells with zinc-compound buffer layers[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2003(0):335-339. |
| [13] | Akira Ichiboshi;Masashi Hongo;Takuya Akamine et al.Ultrasonic chemical bath deposition of ZnS(O,OH) buffer layers and its application to CIGS thin-film solar cells[J].Solar Energy Materials and Solar Cells,2006,90:3130. |
| [14] | Lee J.;Lee S.;Cho S.;Kim S.;Park IY.;Choi YD. .Role of growth parameters on structural and optical properties of ZnS nanocluster thin films grown by solution growth technique[J].Materials Chemistry and Physics,2003(1):254-260. |
| [15] | Hariskos D;Spiering S;Powalla M .Buffer layers in Cu(In,Ga)Se-2 solar cells and modules[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2005(0):99-109. |
| [16] | Dona J M;Herrero F J .Process and film characterization of chemical-bath-deposited ZnS thin films[J].Journal of the Electrochemical Society,1994,141:205. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%