本文设计了用于测量高分子聚合物热导率的改良3ω方法.采用热压的方法将作为加热源和温度传感器的白金(Pt)丝压入待测材料中,利用基于LabVIEW设计的虚拟数字锁相放大技术采集热线两端的3ω电压信号.分析了系统中直流变阻箱感抗对测量结果的影响,在此基础上设计了不加变阻箱的测试系统，简化系统的同时提高了系统在高频下的适用性.最后,利用改进前后的系统在室温下测量了五种高分子聚合物的热导率,测试结果与参考文献值吻合较好,验证了两套系统的可行性.
参考文献
| [1] | Cahill D G;Pohl R O .Thermal Conductivity of Amorphous Solids above the Plateau[J].Physical Review B,1987,35:4067-4073. |
| [2] | 王照亮,唐大伟,郑兴华,布文峰,张伟刚.3ω法测量单根碳纤维导热系数和热容[J].工程热物理学报,2007(03):490-492. |
| [3] | Lu J;Pan DA;Yang B;Qiao LL .Wideband magnetoelectric measurement system with the application of a virtual multi-channel lock-in amplifier[J].Measurement Science & Technology,2008(4):45702-1-45702-5-0. |
| [4] | Zhang Xing;Hendro W;Fujii M et al.Measurements of the Thermal conductivity and Thermal Diffusivity of Polymer Melts with the Short-Hot-Wire Method[J].Inernational Journal of Thermophysics,2002,23(04):1077-1090. |
| [5] | Kline D E .Thermal Conductivity Studies of Polymers[J].Journal of Polymer Science,1961,1:441. |
| [6] | Lobo H;Cohen C .Measurenment of Thermal-Conductivity of Polymer Melts by the Line-Source Method[J].Polymer Eng.Sci,1990,30(02):65-70. |
| [7] | Dashora P.;Gupta G. .ON THE TEMPERATURE DEPENDENCE OF THE THERMAL CONDUCTIVITY OF LINEAR AMORPHOUS POLYMERS[J].Polymer: The International Journal for the Science and Technology of Polymers,1996(2):231-234. |
| [8] | Underwood W M;McTaggart R B .The Thermal Conductivity Of Several Plastics,Measured by an Unsteady State Method[J].Chem.Eng.Progr.Sym,1960,30:61-268. |
| [9] | MARK J E.Polymer Data Handbook[M].,1999:400-401. |
| [10] | Shawn A. Putnam;David G. Cahill;Benjamin J. Ash;Linda S. Schadler .High-precision thermal conductivity measurements as a probe of polymer/nanoparticle interfaces[J].Journal of Applied Physics,2003(10):6785-6788. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%