通过对Y煤的基础性能研究，完成了其用于首钢高炉的可行性评价。与首钢现用A煤相比，Y煤的灰分接近、发热值高、理论置换比高、挥发分略低、硫分略高、可磨性指数相同一致、燃烧性略高。分析认为，Y煤使用后有利于降低燃料比。2009年9月在首钢炼铁厂某高炉进行配喷 Y煤的工业试验，Y煤最高配比为35％，试验期间高炉顺行状况良好，校正置换比由0．80升高至0．83，高炉煤粉利用率较高，达到99％以上，并取得了良好的经济效益。
The basic performance of Y pulverized coal was analyzed ,and the feasibility of injection in Shougang blast furnace was evaluated at the same time .Compared with the coal which used in Shougang blast furnace presently ,the ash content and grindability of Y coal are in the same level ,and the calorific value ,theoretical replacement ratio ,sul-fur content and combustibility are higher ,and volatilization is lower .The analytical results can be concluded that the fuel ratio would be reduced if Y coal is used in Shougang blast furnace .The industry test was carried out in one blast furnace of Shougang ironmaking plant in September ,2009 .The highest injected proportion of Y coal was 35% .Dur-ing test period the blast furnace was in good condition ,the corrected replacement ratio of coal increased from 0 .80 to 0 .83 and coal utilization reached higher than 99% ,which brought good economic benefits .
参考文献
| [1] | 杨天钧;刘应书;杨珉.高炉富氧喷煤[M].北京:科学出版社,1998 |
| [2] | 汤清华;马树涵;王筱留.高炉喷吹煤粉知识问答[M].北京:冶金工业出版社,1997 |
| [3] | 王竹民,刘二浩,吕庆,张淑会.邯钢高炉喷煤煤种的选择研究[J].中国冶金,2009(06):10-14. |
| [4] | 祁成林,张建良,贺鑫杰,闫魁红,刘文文,张华.太钢4350m3高炉喷吹清徐煤特性[J].北京科技大学学报,2011(01):80-86. |
| [5] | 任燕,徐万仁,李军.高炉风口结渣机理的研究[J].炼铁,2004(03):23-27. |
| [6] | Reactivity of pulverized coals during combustion catalyzed by CeO_2 and Fe_2O_3[J].Combustion and Flame,2010(2):351. |
| [7] | 王敏燕,苍大强,王颖茹.用TG-DTA法研究新型燃烧促进剂对煤燃烧性能的影响[J].冶金能源,2008(02):32-34. |
| [8] | 丁智敏,穆林,马晓勇,魏国,沈峰满.混煤及富氧措施提高喷煤量的试验研究[J].中国冶金,2011(02):20-23. |
| [9] | 王再义,邢本策,王相力,裴海玉,张洪宇.高炉喷吹用煤粉的燃烧性能研究[J].中国冶金,2008(12):6-8. |
| [10] | 张华,张建良,柏凌,郭豪.太钢高炉喷吹煤粉燃烧性和反应性的研究[J].炼铁,2008(01):53-56. |
| [11] | 郑涛,吴铿,徐万仁,朱仁良,姜伟忠.高炉炉尘中未消耗煤粉和焦炭比例的研究[J].钢铁,2006(03):20-24. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%