通过对FGH95合金进行不同温度的热等静压（HIP）处理、组织形貌观察及XRD谱线分析,研究了热等静压温度对合金组织与平均点阵常数的影响。结果表明,在低于γ＇相溶解温度热等静压时,合金中粗大γ＇相沿原始颗粒边界区域不连续分布;随热等静压温度提高,合金中粗大γ＇相的数量、尺寸逐渐减小;经1180℃HIP后,合金中粗大γ＇相完全溶解,晶粒尺寸明显长大。由于γ、γ＇两相的平均点阵常数相近,其叠加作用使合金中γ、γ＇两相的X射线衍射峰不对称,对不同温度热等静压合金进行XRD谱线测定及分析表明,随热等静压温度提高,合金中γ、γ＇两相在室温的平均点阵常数略有增大,而晶格错配度的绝对值略有减小。
Influence of HIP temperature on microstructure and average lattice constant of FGH95 nickel-base superalloy after hot isostatic pressing at different temperatures were investigated by means of SEM and XRD analysis.The results show that the coarser γ′ phase is distributed in the prior particle boundary regions when the HIP temperature is lower than solubility of γ′ phase,and the quantity and size of the coarser γ′ phase distributed in the regions decrease as the HIP temperature is raised.After HIP at 1180 ℃,the coarser γ′ phase in the alloy is dissolved and the size of the grain in the alloy obviously grows up.As a result of the close average lattice constants of the γ′,γ phases in FGH95 alloy,the superposition of the diffraction intensity for γ′,γ phases in XRD patterns results in the asymmetry distribution of the diffraction peaks due to the difference of the volume fraction of γ′,γ phases.It is shown by analyzing XRD patterns of the alloy treated by HIP at different temperatures that the average lattice constants of γ′,γ phases at room temperature increases slightly with increasing HIP temperature,but the absolute values of the lattices misfit decrease.
参考文献
| [1] | 张麦仓,罗子健,曾凡昌.致密FGH95合金的高温变形特性研究[J].金属学报,2000(05):507-510. |
| [2] | 李红宇,宋西平,王艳丽,陈国良.FGH95合金中γ'相稳定性研究[J].稀有金属材料与工程,2009(01):64-67. |
| [3] | 田素贵,谢君,周晓明,钱本江,伦建伟,于丽丽,汪武祥.淬火工艺对FGH95合金组织结构与蠕变性能的影响[J].中国有色金属学报,2010(05):852-858. |
| [4] | 田素贵,刘洋,赵忠刚,包宪宇.FGH95粉末镍基合金热处理后的微观组织与蠕变性能[J].航空材料学报,2009(06):33-37. |
| [5] | 刘新灵,陈星,侯学勤,陶春虎.FGH95粉末冶金高温合金损伤与断裂特性研究[J].稀有金属材料与工程,2009(07):1179-1183. |
| [6] | 贾建,陶宇,张义文,张莹.时效制度对粉末冶金高温合金FGH95组织和性能的影响[J].粉末冶金工业,2010(01):25-31. |
| [7] | Glatzel U;Feller-Kniepmeier .Calculation of internal stresses in the γ/γ' microstrueture of a nickel-base superalloy with high volume fraction of γ'-phase[J].Scripta Metallurgica,1989,23(11):1839-1844. |
| [8] | Gilles R;Ukherji D;Tobbens D et al.Neutron X-ray and electron diffraction measurements for the determination of γ'/γ lattice misfit in Ni-base superalloys[J].Applied Physics A:Materials Science and Processing,2002,74(Supp1ement):1446-1448. |
| [9] | Diolngent F;Caron P;Jacques A et al.The γ'/γ mismatch in Ni based superalloys:In situ measurements during creep test[J].Nuclear Instruments and Methods in Physics Research Section B: Beam Interactions with Materials and Atoms,2003,200(06):346-351. |
| [10] | 贾建,陶宇,张义文,张莹.热等静压温度对新型粉末冶金高温合金显微组织的影响[J].航空材料学报,2008(03):20-23. |
| [11] | 王旭青,罗学军,邹金文.热等静压温度对FGH96粉末高温合金显微组织的影响[J].航空材料学报,2006(03):293-294. |
| [12] | M.T. Kim;D.S. Kim;O.Y. Oh .Effect of γ' precipitation during hot isostatic pressing on the mechanical property of a nickel-based superalloy[J].Materials Science & Engineering, A. Structural Materials: Properties, Misrostructure and Processing,2008(1/2):218-225. |
| [13] | 国为民,吴剑涛,张凤戈,张义文,陶宇,陈昆,黄伟,杨静.FGH95镍基粉末高温合金热等静压工艺的研究和发展[J].钢铁研究学报,2003(z1):332-337. |
| [14] | 刘明东,张莹,刘培英,张义文.FGH95粉末高温合金原始颗粒边界及其对性能的影响[J].粉末冶金工业,2006(03):1-5. |
| [15] | 张义文,张莹,张凤戈,杨士仲.固溶温度对FGH95粉末高温合金性能的影响[J].材料热处理学报,2002(03):72-74. |
| [16] | Domingue J A;Boesch W J;Radavich J F.Phase relationships in Rene'95[A].,1980:335-344. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%