用分析纯Ba(OH)2·8H2O和Sr(OH)2·8H2O配制电解液(浓度各为0.2 mol/L),采用微弧氧化技术在工业纯钛板(99.5％)表面原位生成BaxSr(1-x)TiO3铁电薄膜.对不同电流密度、电流频率和反应时间条件下获得的薄膜进行表征,研究了各因素对薄膜物相构成、表面形貌和表面粗糙度的影响.结果表明:所得薄膜均主要由四方相Ba0.5Sr0.5TiO3构成；电流密度为20 A/dm2、电流频率为100 Hz、反应时间为10 min时,所得薄膜最平整、致密、表面粗糙度值最小,且微弧氧化孔洞分布最均匀,测得该薄膜在1 kHz条件下的介电常数为411.3.
参考文献
| [1] | Lahiry S;Mansingh A .Dielectric properties of sol-gel derived barium strontium titanate thin films[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2008(8):1656-1662. |
| [2] | Yanhua Fan;Shuhui Yu;Rong Sun;Lei Li;Yansheng Yin;Ka-Wai Wong;Ruxu Du .Microstructure and electrical properties of Mn-doped barium strontium titanate thin films prepared on copper foils[J].Applied Surface Science: A Journal Devoted to the Properties of Interfaces in Relation to the Synthesis and Behaviour of Materials,2010(22):6531-6535. |
| [3] | Lina Gao;Jiwei Zhai;Xi Yao .The Influence Of Co Doping On The Dielectric, Ferroelectric And Ferromagnetic Properties Of Ba_(0.70)sr_(0.30)tio_3 Thin Films[J].Applied Surface Science: A Journal Devoted to the Properties of Interfaces in Relation to the Synthesis and Behaviour of Materials,2009(8):4521-4525. |
| [4] | WU Tai-bor;WU Chi-ming;CHEN Mei-ling .Dielectric and leakage current characteristics of Ba(Ti1-xZrx)O3 thin films deposited by rfmagnetron sputtering[J].Thin Solid Films,1998,334(1-2):77-81. |
| [5] | Dielectric and structural characterization of KNbO_3 ferroelectric thin films epitaxially grown by pulsed laser deposition on Nb doped SrTiO_3[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2010(12):p.3432. |
| [6] | Jinbao Xu;Yun Liu;Ray L et al.Electric characteristics of BaTiO3/Bi0.5 K0.5 TiO3 multilayered thin films synthesized via metalloorganic decomposition[J].Solid State Ionics,2009,180(17-19):1118-1120. |
| [7] | Markov G A;Markova G V .A method of forming anodes of electrolytic condensers[P].USSR Inventor's Certificate No.526961,1984-01-01. |
| [8] | 姜兆华,李文旭,闫久春,李益民.微等离子体氧化法制备钛酸钡陶瓷膜[J].材料工程,2002(02):34-37. |
| [9] | Van T B;Brown S D;Wirtz G P .Mechanism of anodic spark deposition[J].American Ceramic Society Bulletins,1977,56(06):563-566. |
| [10] | Dittrich K H;Krysmann W;Kurze P et al.Structure and properties of ANOF layers[J].Crystal Research and Technology,1984,19(01):93-99. |
| [11] | 旷亚非,许岩,李国希.铝及其合金材料表面处理研究进展[J].电镀与精饰,2000(01):16-20. |
| [12] | 宋润滨,左洪波,吉泽升.轻合金等离子体增强电化学表面陶瓷化进展[J].轻合金加工技术,2003(02):8-11. |
| [13] | 韩冰 .微弧氧化法沉积BaTiO3铁电薄膜的研究[D].广州:华南理工大学,2007. |
| [14] | 黄文波 .微弧氧化法生成ABO3型铁电薄膜研究[D].广州:华南理工大学,2010. |
| [15] | 王亚明,蒋百灵,雷廷权,郭立新,曹跃平.电参数对Ti6Al4V合金微弧氧化陶瓷膜结构特性的影响[J].无机材料学报,2003(06):1325-1330. |
| [16] | 王国强,王安福,王绍明.Sol-Gel法制备BST铁电薄膜及性能研究[J].武汉理工大学学报,2007(05):10-12,52. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%