研究了水/甲苯乳化液中二苯并噻吩(硫芴,DBT)在分散型钼酸和磷钼酸催化剂存在下的加氢脱硫反应.反应在高压釜中于340℃及经水煤气转换反应(WGSR)产生的原位氢存在下进行.用GC和GC-MS 鉴定、分析了气体和液体产物的组成.结果表明:在反应过程中部分加氢的中间产物1,2,3,4-四氢硫芴(4H-DBT)和1,2,3,4,10,11-六氢硫芴(6H-DBT)的浓度相当高,但二联苯的浓度相对较低,说明加氢路径与氢解路径相当.提出的硫芴加氢脱硫反应网络包含两个反应途径:噻吩环先直接氢解脱硫,紧接着苯环加氢途径;苯环先加氢,然后噻吩环氢解脱硫途径.同时,还包含环烷环的异构化反应.
The hydrodesulfurization (HDS) of dibenzothiophene (DBT) in H2O/C6H5CH3 emulsion was investigated using dispersed catalyst precursors molybdic acid and phosphomolybdic acid. The HDS experiments were performed in an autoclave at 340℃ using in situ generated hydrogen from CO/H2O via the water gas shift reaction. The results indicated that the partially hydrogenated intermediates 1, 2, 3, 4-tetrahydrodibenzothiophene and 1, 2, 3, 4, 10, 11-hexahydrodibenzothiophene were present in quite high concentration, while diphenyl was present in a relatively lower concentration, so the hydrogenation route is comparable to the hydrogenolysis route.A reaction network involving two pathways, direct hydrogenolysis-hydrogenation, and hydrogenation-hydrogenolysis, as well as isomerisation of aliphatic rings was proposed.
参考文献
| [1] | Ng F T T;Tsakiri S K .[J].Fuel,1992,71(11):1309. |
| [2] | NgFTT;RintjemaRT .[J].Studies in Surface Science and Catalysis,1992,73:51. |
| [3] | Ng F T T;Walker G R .[J].Canadian Journal of Chemical Engineering,1991,69(04):844. |
| [4] | Takemura Y;Itoh H;Ouchi K .[J].Sekiyu Gakkaishi,1981,24(06):357. |
| [5] | GadallahFF;MohammedPT .[J].Studies in Surface Science and Catalysis,1984,19:577. |
| [6] | Batchelder R F;Fu Y C .[J].Industrial & Engineering Chemistry Process Design and Development,1979,18(04):594. |
| [7] | Kumar M;Akgerman A;Anthony R G .[J].Industrial & Engineering Chemistry Process Design and Development,1984,23(01):88. |
| [8] | Hook B D;Akgerman A .[J].Industrial & Engineering Chemistry Process Design and Development,1986,25(01):278. |
| [9] | Fu Y C;Ishikuro K;Fueta T et al.[J].Energy and Fuels,1995,9(03):406. |
| [10] | Fu Y C;Akiyoshi M;Tanaka F et al.Prep Pap-Am Chem Soc[J].Division of Fuel Chemistry,1991,36:1887. |
| [11] | Houalla M;Nag N K;Sapre A V et al.[J].AICHE Journal,1978,24(06):1015. |
| [12] | Silverstein R M;Bassler G C;Morrill T C.Spectrometric Identification of Organic Compounds, 4th Ed[M].New York:John Wilsey & Sons Inc,1981:9. |
| [13] | Porter Q N;Baldas J.Mass Spectrometry of Heterocyclic Compounds[M].New York:John Wilsey & Sons Inc,1971:264. |
| [14] | Stenhagen E;Abrahamsson S;McLafferty F W.Atlas of Mass Spectral Data[M].New York:Interseience Publisher,1994:1298. |
| [15] | Dietz W A .[J].Journal of Gas Chromatography,1967,5(02):68. |
| [16] | Broderick D H;Gates B C .[J].AICHE Journal,1981,27(04):663. |
| [17] | Curtis C W;Chen J H;Tang Y .[J].Energy and Fuels,1995,9(02):195. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%