材料期刊网

Cooling Efficiency of Laminar Cooling System for Plate Mill

ZHANG Dianhua , WANG Bingxing , ZHOU Na , YU Ming , WANG Jun

钢铁研究学报(英文版)

Heat transfer was researched from a perspective of the industry application. On the basis of the first law of thermodynamics, the cooling efficiency was deduced from the change of enthalpy inside hot plate. The relationship between the cooling efficiency and its influencing parameters was regressed from plenty of data collected from the worksite and discussed in detail. The temperature profiles resulting from the online model and the model modified by regressed formulas were presented and compared. The results indicated that the control accuracy of the modified model was increased obviously.

关键词: hot rolled plate;laminar cooling;cooling efficiency;temperature profile

A Kind of Plate Laminar Cooling Strategy with High Response and Steady Precision

ZHOU Na

钢铁研究学报(英文版)

After Smith Predictor being used to laminar cooling system, the control law for integral regulators is introduced. New notion of plate sample length is given evading the delay time varying with the roll table speed. It is found that the integral algorithm is more controllable for system regulating process and has better steady-state precision. Compared with the traditional control strategies the new control law has faster response speed and higher steady-state precision. The controller can regulate in shorter time and response faster than routine controller and it can effectively eliminate the oscillatory instability. Owing to its easy realization and high stability, it has been applied in a plate mill. The accuracy of finish cooling temperature can be controlled in ±10℃.

关键词: ;plate;laminar cooling;Smith Predictor;time delay system

Na+对KDP晶体生长的影响

梁晓亮 , 王波 , 孙洵 , 顾庆天 , 丁建旭 , 许心光

人工晶体学报

本文利用传统的降温法和"点籽晶"快速生长法在不同Na+掺杂浓度的溶液中生长KDP晶体,定量研究了Na+对KDP晶体生长的影响.实验发现:Na+的存在降低了溶液的稳定性,致使KDP晶体柱面容易扩展.Na+的存在对KDP晶体的光学性能基本没有影响.

关键词: KDP晶体 , 晶体生长 , 柱面扩展

EFFECT OF Na,K AND Ce ON CRACK PROPAGATION RESISTANCE FOR ALLOY 8090

MENG Liang ZHANG Baochang LIANG Ying ZHANG Weizhong TIAN Puke Northwestern Polytechnical University , Xi'an , China

金属学报(英文版)

The crack propagation resistance for alloy 8090 sheet decreases with the increase of content of Na and K impurities.An improvement over the fracture toughness and crack initiation resist- ance for the alloy containing Na and K within certain limit may be made by adding 0.05% Ce.This beneficial modification would not be manifested if the alloy contained more Na and K.One of the reasons why Na and K injure the toughness of the alloy might be due to that they cause the precipitation of T_1 phase along grain and subgrain boundaries and accelerate the abnormal growth of recystallized grains.

关键词: alloy 8090 , null , null , null , null

催化Na2SO3除氧的研究

邵忠宝 , 赵敬棋

腐蚀学报（英文）

研究了Na2SO3的除氧效果，讨论了pH值、Ca和Mg 离 子浓度、催化剂Co(NO3)2的浓度对Na2SO3除氧效果的影响.实验结果表明：在无催 化剂存在的情况下，Na2SO3的除氧率最高仅达到90%.Ca、Mg离子浓度对Na2SO3的 除氧效果有一定的抑制作用，使除氧率降低约4%～6%.催化剂Co(NO3)2的引入，能够明 显地提高Na2SO3的除氧率，降低Na2SO3的用量，当Na2SO3加入量过剩约5.0 mg /L，催化剂Co(NO3)2的加入量为1.5 mg/L时，除氧率大于99.5%，且Ca、Mg离子浓度及p H值对其除氧率影响很小.

关键词: Na2SO3 , catalyst , Co(NO3)2 , rate of deoxidation

催化Na2SO3除氧的研究

邵忠宝 , 赵敬棋

腐蚀学报（英文） doi:10.3969/j.issn.1002-6495.2002.01.013

研究了Na2SO3的除氧效果,讨论了pH值、Ca和Mg离子浓度、催化剂Co(NO3)2的浓度对Na2SO3除氧效果的影响.实验结果表明:在无催化剂存在的情况下,Na2SO3的除氧率最高仅达到90%.Ca、Mg离子浓度对Na2SCO3的除氧效果有一定的抑制作用,使除氧率降低约4%～6%.催化剂Co(N鸭)2的引入,能够明显地提高Na2SO3的除氧率,降低Na2SO3的用量,当Na2SO3加入量过剩约5.0 mg/L,催化剂Co(NO3)2的加入量为1.5 mg/L时,除氧率大于99.5%,且Ca、Mg离子浓度及pH值对其除氧率影响很小.

关键词: Na2SOO3 催化剂 Co(NO3)2 除氧率

Na掺杂ZnO薄膜的表面形貌及其光学性质

吕建国 , 陈学梅 , 朱剑博 , 黄凯 , 宋学萍 , 孙兆奇

人工晶体学报

采用溶胶-凝胶技术制备不同Na掺杂ZnO薄膜,用XRD、拉曼光谱仪、AFM、SEM和紫外可见分光光度计等表征方法研究了Na掺杂量对ZnO薄膜的表面形貌和光学性质的影响.XRD和Raman光谱分析表明:8.0 at%Na掺杂ZnO薄膜具有最佳c轴择优取向,内部残余张应力最大;表面形貌研究结果显示:薄膜的平均粒径和粗糙度均随Na含量的增加而增大.薄膜在可见光范围内的平均透射率大于80%,随着Na含量从0增加到10at%,薄膜的光学带宽由3.283 eV增大到 3.305 eV.

关键词: Na掺杂 , 拉曼光谱 , 表面形貌 , 透射谱

Na-Ca-Si玻璃的微塑性

罗劼 , 金宗哲 , 何欧里

材料研究学报

<正> 作为脆隆材料的Na-Ca-Si 玻璃,其纤维的应力应变曲线明显地偏离完全弹性,用Vickeis 金刚石尖压痕研究Na-Ca-Si 玻璃时,也发现许多偏离弹性的现象。如:压痕痕迹不消火,压痕丧丽上出现凸起~([1]),压痕下而出现位错线~([2])。本文设计了一种新的试验,用Vickers 压痕研究Na-Ca-Si 玻璃的微塑性。

关键词:

Short-range order in liquid Na-Cd alloys

Journal of Physics-Condensed Matter

We present a detailed study of both the topological and the chemical short-range orders for liquid Na-Cd alloys using interatomic potentials derived from a non-local model pseudopotential theory. First, the mixing entropy is predicted using a hard-sphere Yukawa reference system, with the parameters being measured from the pseudopotential-calculated mean interatomic interactions and the ordering potentials. It is found that the ordering contribution to the entropy reaches its largest magnitude at around 30 to 50 at.% (atomic per cent) of Na, while above 70 at.% Na, the contribution is small. Then, the atomic structures are calculated using molecular dynamics simulations combined with an energy mapping technique. From the careful examination of the calculated structural distribution functions, the chemical shea-range-order parameters and the pair analysis results, we found that with increasing Na concentration, the Na-Cd alloy system exhibits a chemical ordering tendency from compound forming to phase separation, and a topological ordering tendency from a Cd-like structure characterized by 1311- and 1422-type atomic bonded pairs to a Na-like one characterized by 1551-type atomic bonded pairs.

关键词: thermodynamic properties;binary-alloys;ga

Preparation and Gas-sensing Characteristics of Na~+-doped ZnO Single Crystals

Suying PAN and Junbiao MAO (Center for Materials Research and Analysis , Wuhan University of Technology , Wuhan , 430070 , China)(To whom correspondence should be addressed)

材料科学技术（英文）

ZnO single crystals were grown by vapor phase reaction of Zno powder with active carbon powdei at an elevated temperature The typical crystals were colorless and transparent with maximum size o4 0.1 mm in diameter and 25 mm in length, The gas-sensing characteristics of Na+-doped anc undoped single crystals were investigated in 1 %H2. Co and CH, in air between 1 50 and 600℃. It was found that the undoped ZnO single crystals showed little gas sensitivity in air. and Na+-doping can greatly enhance the senstivity by increasing the resistivities. The maximum sensitivity of the samples is 22 (Ra/ Rg) for H2. 1 2 for CO and 4 for CH4

关键词: